outside house boiler

Industrial boilers

Product thermal capacity: 4-35 t/h

Working pressure: 1.0-2.5 MPA

Outlet temperature: 184-350 ℃

Available fuel: natural gas, coke oven gas, bio-gas,liquid propane gas, diesel, heavy oil, light oil, crude oil

Available industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries

  • Product introduction
  • Technical advantages
Introduction

outside house boiler have a three-pass round coil structure. A conical coil is used for the effective protection of the furnace wall at the boiler end. This product is equipped with an advanced combustion device and is fully automated in operation. After the burner ignites the fuel, flame fills the round coil tubes and transfers heat by radiation through the tube wall (first pass). The high temperature flue gas gathers at the back door and then turns to the convection tubes section (second pass), where heat transfer takes place by convection. The flue gas gradually cools down here and flows to the front door, where it is reversed and goes into the third pass. After that, it enters into the chimney through the economizer and is released into the atmosphere.


outside house boiler.This type of heater is delivered as a whole, and is installed on site, it only needs to connect thermal gas(oil) piping and electricity to start operation. The heater has four heating areas: furnace radiation heating area, the first convection tube bundle heating area, the second convection tube bundle heating area and economizer (waste heat boiler).

Digitized manufacture
  • The laying-off of steel tube adopts CNC 3D laser cutting machine.
  • The manufacture of round coil tube adopts CNC coil tube automatic production line. Once-forming and no need for plastic .
Full argon arc welding
  • The tube butt adopts argon arc welding technique and the seams will be done x ray real-time imaging, preventing unqualified seams from entering coil production line .
Easy operation
  • Heater is wholly assembled before delivery, it is easy for installation, debugging and operating.
  • Fully automatic operating, burning, liquid level of high level tank, outlet temperature and flow rate are adjusted automatically and self-protected.
  • The inlet and outlet with end flanges and flanged cover structure facilitate the installation and layout of tubeline in boiler house.
Less fuel consumption
  • Internal side adopts good insulation material, outside uses stainless steel plate, which can mostly reduce heat lost and make working environment better.
  • Multilayers closely spaced tube bundle and steel rod is used to seal and fix, completely eradicating short circuit of flue gas.
  • Before delivery, the residue moisture is removed completely, so the system draining period is reduced to 2 days from 12 days.
Safely operation
  • The inner coil tube has bigger flow rate, so it is more stable under high temperature operation.
  • Conical coil effectively protects the furnace wall at the end of heater and burner on the top.
outside house boiler outside house boiler outside house boiler

Can a boiler be installed without having to go to th

2019-6-15 · Is it possible for a boiler to be installed without the installation person having to go to the outside of the house ? I am in a flat on the 2nd floor of a converted mid terrace house, the kitchen where the current boiler is installed faces the back garden however i have no access to the back garden and the only way to get to it is to go via the downstairs neighbour's flat.

lexie@zozen.com > Get A Quote >

Is is safe to run a gas pipe externally to a new boile

Is is safe to run a gas pipe externally to a new boiler? I am considering a new boiler from tank system to combi, I was told the gas pipe to the new boiler would run up the external wall on the outside from the gas meter to the new boiler situated in the airing cupboard 1st floor. Is it safe to run this pipe outdoors or should it be sited

lexie@zozen.com > Get A Quote >

Central Heating Boiler Vents - MyBuild

the type of boiler that you have draws the air for combustion from the surrounding area so provision for this must be provided by vents etc. if the boiler is on the ground floor and if the ceiling joists run towards the outside wall it would be possible to fit a vent in the cupboard ceiling and an air brick in the outside wall, this should be sufficient, my boiler fitted some 20 years ago in

lexie@zozen.com > Get A Quote >

water constant drip outside from boiler | Screwfi

2013-4-3 · water constant drip outside from boiler. You can find it by tracing the (usually) 15mm pipe which comes out from your boiler and heads out through the house wall - that's the one that's dripping! If you have a 'handy' friend who's done this kind of task before, then it shouldn't be much effort for them to check out yours too.

lexie@zozen.com > Get A Quote >

Water coming from overflow outside house

1. Look where the overflowing pipe comes out of your house. Is it from the eaves of the roof, near a bathroom / toilet or near a boiler/hot water cylinder. 2.Look at the type of pipe the water is coming from what is the material is it metal of plastic. Plastic pipe from eaves – constant flow

lexie@zozen.com > Get A Quote >

Is is safe to run a gas pipe externally to a new boile

Is is safe to run a gas pipe externally to a new boiler? I am considering a new boiler from tank system to combi, I was told the gas pipe to the new boiler would run up the external wall on the outside from the gas meter to the new boiler situated in the airing cupboard 1st floor. Is it safe to run this pipe outdoors or should it be sited

lexie@zozen.com > Get A Quote >

Outside Coal Boiler or Inside Boiler Outside? | Stoke

2011-9-18 · There are a couple of manufacturer's of outside coal boilers. Mainly used in Canada but I belive they are available in the states. Coalman comes to mind. Do a internet search and see. They are not cheap. Personally, I do not like outside boilers coal or wood. I recommend building an outbuilding and put the boiler inside that.

lexie@zozen.com > Get A Quote >

Online Boiler Quote | BoilerChoice.c

If you are connected to mains gas and have a gas meter at your house, the likelihood is your boiler is gas and select this option. LPG. Info Select. LPG is short for Liquid Petroleum Gas. If you have a fuel tank outside your house, in most cases you will not be connected to mains gas and select this option.

lexie@zozen.com > Get A Quote >

Water coming from overflow outside house

1. Look where the overflowing pipe comes out of your house. Is it from the eaves of the roof, near a bathroom / toilet or near a boiler/hot water cylinder. 2.Look at the type of pipe the water is coming from what is the material is it metal of plastic. Plastic pipe from eaves – constant flow

lexie@zozen.com > Get A Quote >

Central Boiler Outdoor Wood Furnace Prices and Revi

2019-6-15 · This Central Boiler outdoor wood boiler review includes information about the brand's EPA certified residential models. Features and Central Boiler costs are included. If you're just beginning research on wood furnaces and boilers, then our Outdoor Wood Boilers and Furnaces Guide is a great place to start. The comprehensive guide includes

lexie@zozen.com > Get A Quote >

Oil Burner - Inside or Outside the house?

2005-1-11 · oil burner- inside or outside? Transporting heat costs money,especially through the cold outside.The ordinary boiler could freeze and burst if not in use.The standard chimney is not used.Instead they use a short pipe out of a zinc coated steel box covering the boiler.That could cause pollution of the air that is supposed to come freshly in to the house /the window.10% more loss of energy is

lexie@zozen.com > Get A Quote >